Ignition timing control system
| Spark plug | |
|---|---|
| Spark plug gap | 0.8-0.9 mm (0.031-0.035 in) |
| Spark plug wire | |
| Resistance | 1.9-5.0 kΩ @ 20 °C (68 °F) |
| Ignition coil | |
| Primary coil resistance | 1.530-2.070 Ω @ 20 °C (68 °F) |
| Secondary coil resistance | 12.50-16.91 kΩ © 20 °C (68 °F) |
| Pulser coil | |
| Air gap | 0.5-1.0 mm (0.020-0.039 in) |
| Output peak voltage (reference data) | 7.9 V @ cranking (unloaded) 7.2 V @ cranking (loaded) 20.7 V @ 1500 r/min (loaded) 32.0 V @ 3500 r/min (loaded) |
| Resistance | 396.0-594.0 Ω @ 20 °C (68 °F) |
| Intake air pressure/temperature sensor | |
| Input voltage | 4.75-5.25 V |
| Thermo sensor | |
| Input voltage | 4.75-5.25 V |
| Resistance (reference data) | 2.439 kΩ @ 20 °C (68 °F) 0.589 kΩ @ 60 °C (140 °F) 0.193 kΩ @ 100 °C (212 °F) |
| Shift position switch | |
| Input voltage | 4.75-5.25 V |
Fuel injection control system
| Water detection switch | |
|---|---|
| Input voltage | 4.75-5.25 V |
| Fuel injector | |
| Input voltage | 12 V |
| Resistance (reference data) | 12.00 Ω @ 20 °C (68 °F) |
| High-pressure fuel pump | |
| Input voltage | 12 V |
| Resistance (reference data) | 0.2-3.0 Ω @ 20 °C (68 °F) |
| Vapor shut-off valve | |
| Input voltage | 12 V |
| Resistance | 30.0-34.0 Ω @ 20 °C (68 °F) |
Engine speed control system
| TPS | |
|---|---|
| TPS output voltage (reference data) | 0.978 V @ throttle valve fully closed 4.213 V @ throttle valve fully open |
| Input voltage | 4.75-5.25 V |
| ISC valve | |
| Resistance | 27.0-33.0 Ω @ 20 °C (68 °F) |
| Oil pressure switch | |
| Working pressure | 49.00 kPa (0.490 kgf/cm2, 7.11 psi) |
PTT system
| Trim sensor | |
|---|---|
| Free position resistance (reference data) | 168-285Ω |
| Setting resistance | 9.0-11.0 Ω |
Charging system
| Lighting coil | |
|---|---|
| Output peak voltage (reference data) | 13.2 V @ cranking (unloaded) 42.2 V @ 1500 r/min (unloaded) 96.6 V @ 3500 r/min (unloaded) |
| Resistance (reference data) | 0.5100-0.6300 Ω @ 20 °C (68 °F) |
| Fuse | 20 A |
| Rectifier/Regulator | |
| Output voltage | 13 V @ 1500 r/min (loaded) 13 V @ 3500 r/min (loaded) |
Starting system
| Starter motor | |
|---|---|
| Type | Sliding gear |
| Output | 1.40 kW |
| Cranking time limit | 30 seconds |
| Commutator | |
| Standard diameter | 29.0 mm (1.14 in) |
| Wear limit | 28.0 mm (1.10 in) |
| Standard undercut | 0.8 mm (0.03 in) |
| Wear limit | 0.2 mm (0.01 in) |
| Brush | |
| Standard length | 15.5 mm (0.61 in) |
| Wear limit | 9.5 mm (0.37 in) |
Y-COP
| Remote control receiver | |
|---|---|
| Input voltage | 12 V |
| Buzzer | |
| Input voltage | 12 V |
| Button cell battery - CR2016 | |
| Battery voltage (reference data) | 3 V |
Gauge/sensor
| Water pressure sensor | |
|---|---|
| Input voltage | 4.75-5.25 V |
| Output voltage (reference data) | 2.5 V @ 392.0 kPa (3.92 kgf/cm2, 56.8 psi) 4.5 V @ 784.0 kPa (7.84 kgf/cm2, 113.7 psi) |
| Speed sensor | |
| Input voltage | 4.75-5.25 V |
| Output voltage (reference data) | 2.5 V @ 392.0 kPa (3.92 kgf/cm2, 56.8 psi) 4.5 V @ 784.0 kPa (7.84 kgf/cm2, 113.7 psi) |
