Service Manual 5008853_15 HP Bracket [Parts Layout]

Produtos Relacionados:

added 4 de setembro de 2020 às 00:00 updated 19 de janeiro de 2021 às 19:55

BRP Marine

Sections:

P/L Fig. 13

Ref.No	Description	Q'ty	Remarks
1	Drive Shaft Housing "S" Drive Shaft Housing "L"	1
1-1	Exhaust Plug	1
2	Oil Seal, 12.8-25-7	1	Do not reuse
3	Drain Bolt	1
4	Washer, 14.5-24-1	1
5	Dowel Pin, 6-12	2
6	Cam Rod Holder	1	for Transom "L" & "XL"
7	Bolt	2
8	Idle Exhaust Port Grommet	1
9	Idle Exhaust Port Cover	1
10	Idle Exhaust Port Plate	1	Do not reuse
11	Bolt	3
12	Idle Exhaust Port Gasket	1
13	Bolt	8
14	Engine Basement Seal	1
15	Extension Housing "XL"	1	for Transom "XL"
16	Stud Bolt	4
17	Washer, 8.1-16-1.5	4	for Transom "XL"
18	Nut	4
19	Drive Shaft Busing	1
20	Bushing Stopper	1
21	Bolt	2
22	Lock Plate	1	for Transom "XL"
23	Water Pipe Auxiliary Mount	1
24	Screw	1
25	Water Pipe "S" Water Pipe "L" Water Pipe "XL"	1 1 1	for Transom "S" for Transom "L" for Transom "XL"
26	Water Pipe Auxiliary Mount	1
27	Water Pipe Lock Plate	1
28	Water Pipe Seal (Upper)	1
29	Rubber Mount (Upper) Rubber Mount (Upper)	2 2	for Transom "S" & "L" for Transom "XL"
30	Bolt	4
31	Drive Shaft Housing Cover (Right)	1	Starboard
32	Drive Shaft Housing Cover (Left)	1	Port
33	Apron Seal	2
34	Tapping Screw, 6-60	4
35	Oil Drain Grommet	1

P/L Fig. 18

Ref.No	Description	Q'ty	Remarks
1	Swivel Bracket	1
2	Steering Shaft Ass'y	1
3	Busing, 28-31-35	2
4	Thrust Plate, 28.5-48-1	2
5	O-Ring, 3.5-25.7	1
6	Grease Fitting	3
7	Damper (Lower)	2
8	Rubber Mount (Lower)	2
9	Mount Bracket (Right)	1	Starboard
10	Mount Bracket (Left)	1	Port
11	Bolt	1
12	Bolt	2
13	Nut	3
14	Washer, 8.1-16-1.5	3
15	Stud Bolt, 10-95	2
16	Nylon Nut	2
17	Washer	2
18	Anode	1
19	Bolt	1
20	Ground Cable	3	L=130
21	Bolt	3
22	Bolt	1	Clamp Bracket "R"
23	Co-Pilot Handle	1	for R & TE
24	Washer, 8.1-20-0.8	1
25	Co-Pilot Bolt	1
26	Nylon Nut (2T), M8-P1.25	1	for R & TE
27	Co-Pilot Plate	1
28	Bolt	2
29	Co-Pilot Washer	1
30	Co-Pilot Disk	2	for R & TE

P/L Fig. 19

Ref.No	Description	Q'ty	Remarks
1	Clamp Bracket (Right)	1	Starboard
2	Clamp Bracket (Left)	1	Port
3	Clamp Screw Ass'y	2
3-1	Clamp Screw	2	M14 P2.0
3-2	Clamp Screw Handle	2
3-3	Rivet, 3-22	2
4	Clamp Screw Pad	2
5	Swivel Bracket Shaft	1	Bracket Bolt
6	Nylon Nut, 7/8	1
7	Bracket Shaft Bushing	2
8	Distance Piece	1
9	Washer	4
10	Nut	2
11	Thrust Rod Ass'y	1
11-1	Thrust Rod Spring	1
12	Bracket Shaft Cap	2	for R & TE
13	Tilt Stopper	1
14	Spring Pin, 5-40	1
15	Bushing, 8.2-10-26.5	1
16	Tilt Stopper Setting Plate	1
17	Bolt	2
18	Tilt Stopper Friction Spring	1
19	Setting Piece	1
20	Anode	1
21	Bolt	1
22	Reverse Lock Link Lever	1
23	Reverse Lock Lever Grip	1
24	Grip Stopper	1
25	Washer, 6-16-1.5	1
26	Reverse Lock Lever Shaft	1
27	Wave Washer, d=8	1
28	Reverse Lock "A"	1
29	Reverse Lock Arm	1
30	Reverse Lock Shaft "A"	1
31	E-Ring, d=6	2
32	Reverse Lock Rod "A"	1
33	Split Pin, 2-12	1
34	Reverse Lock Link "A"	1
35	Reverse Lock Link Spring	1
36	Reverse Lock Spring	2
37	Co-Pilot Decal	1
38	Bolt	4
39	Nut	4
40	Washer	8

P/L Fig. 12

Ref.No	Description	Q'ty	Remarks
1	Tiller Handle	1	for R & TE
2	Plastic Rivet, 6.5	1
3	Stud Bolt	2
4	Grip	1
5	Throttle Decal	1	for R & TE
6	Throttle Shaft	1
7	Throttle Shaft Damper	1
8	Bushing, 8.4-10-11	1
9	Screw	1
10	Throttle Shaft Supporter	1	for R & TE
11	Screw	1
12	Friction Piece	1
13	Adjusting Screw	1
14	Nut	1
15	Washer	1
16	Throttle Cable	2
17	Protector Tube	1	for R & TE
18	Tiller Handle Bushing	1
19	Washer, 39-52-1	1
20	Wave Washer, 39.5-52-1.2	1
21	Tiller Handle Cover	1	for R & TE
22	Nut	2
23	Washer	2
24	Steering Bracket	1
25	Bolt, 10-80 P1.5	2	for R & TE
26	Washer	2

P/L Fig. 20

Ref.No	Description	Q'ty	Remarks
1	Bottom Cowl	1
2	Bolt	4
3	Rubber Mount Washer	4
4	Rubber Mount, 8.5-14-2.5	8
5	Spacer, 6.2-9-15.7	4
6	Battery Cable Grommet	1
7	Shift Rod Grommet	3
8	Shift Lever Bracket Seal	1
9	Grommet, 17-2.7	1	for R & E
10	Grommet	1
11	Grommet	1
12	Grommet	1
13	Water Nipple	1
14	Fuel Connector (Engine, Male)	1
15	Bolt	1
16	Fuel Connector Protector	1
17	Rubber Hose	1
18	Fuel Hose Protector	1	ø10.7-280
19	Grommet, 22-2.5	1
20	Clip ø9.5	2
21	Cowl Latch Ass'y	1
22	Bolt	1
23	Storage Decal	1

P/L Fig. 16

Ref.No	Description	Q'ty	Remarks
1	Neutral Switch Bracket	1
2	Shift Lever Shaft Holder	1
3	Bolt	3
4	Shift Lever Shaft	1
5	Shift Lever Stopper	2
6	Shift Lever Stopper Plate	1
7	Bolt	1
8	Stop Switch	1
8-1	Stop Switch Lanyard	1
9	Shift Arm	1	for R & TE
10	Shift Lever Bracket	1
11	Bolt	2
12	Throttle Dram	1
13	Collar, 6.1-14-8.9	1	for R & TE
14	Bolt	1
15	Shift Lever	1
16	Collar, 6.5-10.5-22.6	1	for R & TE
17	Bolt	1
18	Shift Lever Rod	1	for R & TE
19	Throttle Cable Bracket	1
20	Bolt	1
21	Shift Lever Rod Grommet	1	for R & TE
22	Shift Lever Bracket Cover	1
23	Screw	1
24	Throttle Rod	1	for R & TE
25	Shift Decal (F, N, R)	1
26	Main Switch	1	for TE
27	Neutral Switch	1

P/L Fig. 17

Ref.No	Description	Q'ty	Remarks
1	Shift Lever Shaft	1
2	Shift Lever Stopper	2
3	Shift Lever Stopper Plate	1
4	Bolt	1
5	Shift Arm (Remote Control)	1	for E
6	Remote Control Cable Stay	1
7	Bolt	3
8	Cable Clip	1	for E
9	Bolt	1
10	Cable Grommet	1
11	Remote Control Stay Cover	1
12	Bolt, 5-35 (with Washer)	2
13	Shift Lever Rod	1	for E
14	Nut	1
15	Spacer, 5-9.5-5	1
16	Split Pin, 2-12	1	for E
17	Cable Joint	3
18	Washer, 8.5-18-1.6	3
19	Snap Pin, d=8	3	for E
20	Shift Lever (Remote Control)	1
21	Bolt	1
22	Washer, 6-16-1.5	2
23	Collar, 6.2-9-9.3	1	for E
24	Rod Snap, 5-3	1
25	Throttle Rod (Remote Control)	1
26	Rod Snap, ø3-B	1
27	Throttle Lever (Remote Control)	1	for E
28	Bolt	1
29	Washer, 6-16-1.5	2
30	Collar, 6.2-9-30.8	1	for E
31	Throttle Lever Stopper	1
32	Bolt	1
33	Steering Bracket	1	for E
34	Bolt	2
35	Washer	2
36	Drag Link "H"	1
36-1	Drag Link Spacer	1	for E
36-2	Bolt, 3/8-50	1
36-3	Nylon Nut, 3/8	2
36-4	Washer, 9.6-18-2	3
36-5	Drag Link Seal Ring	1	for E
37	Cord Ass'y	1
38	Clamp, 6.5-120P	1
39	Bolt	1
40	Remote Control Box (RC5B)	1

Share on social:

$71.60